欢迎访问沈阳真空杂志社 Email Alert    RSS服务

真空 ›› 2025, Vol. 62 ›› Issue (6): 47-53.doi: 10.13385/j.cnki.vacuum.2025.06.07

• 真空获得与设备 • 上一篇    下一篇

基于真空脉动循环参数调控的管腔结构蒸汽穿透机制研究*

雷丽, 郑伟, 孙立红, 李又聪   

  1. 中国人民解放军联勤保障部队第九六四医院,吉林 长春 130062
  • 收稿日期:2025-03-03 出版日期:2025-11-25 发布日期:2025-11-27
  • 作者简介:雷丽(1973-)女,吉林长春人,本科。
  • 基金资助:
    *吉林省卫生健康科技能力提升项目(2021LC112)

Study on the Steam Penetration Mechanism in Tubular Structures Based on Vacuum Pulsation Cycle Parameter Regulation

LEI Li, ZHENG Wei, SUN Lihong, LI Youcong   

  1. The 964th Hospital of the Joint Logistic Support Force of the People's Liberation Army of China, Changchun 130062, China
  • Received:2025-03-03 Online:2025-11-25 Published:2025-11-27

摘要: 针对微米级管腔结构中蒸汽渗透效率低、分布不均的问题,本文研究真空脉动循环参数对蒸汽传质的调控机制,提升穿透性能与能效利用率。构建频率(0.5~2.0 Hz)与压力幅值(5~15 kPa)耦合的蒸汽扩散动力学模型,结合计算流体力学(CFD)模拟,揭示脉动压力场对蒸汽相变与边界扰动的影响规律。搭建真空脉动实验平台,集成高速显微成像与X射线微CT,量化分析不同参数下的蒸汽穿透深度与三维分布,并采用响应面法优化参数组合。结果表明,脉动条件下穿透均匀性提升约21%,末端饱和度达0.78±0.05,较静态工况提升约50%。在1.2 Hz/10 kPa参数组合下,实现单位能效指标(η=5.06 s/J)最优,较基准工况提升约40%,对应关键性能指标KPI达2.37 g/(kW·s),较标准提升58%。研究表明,真空脉动参数可协同强化蒸汽传质与能效控制,显著改善微结构渗透性能,为微通道干燥、器械灭菌及多孔介质传质提供理论依据与优化路径。

关键词: 真空脉动, 微尺度管腔结构, 蒸汽穿透效率, 循环参数调控, CFD模拟

Abstract: To address the challenges of low steam penetration efficiency and uneven distribution in microscale lumen structures, this study investigates the regulatory mechanism of vacuum pulsation parameters on steam mass transfer, aiming to improve penetration performance and energy utilization. A steam diffusion dynamics model coupling pulsation frequency (0.5~2.0 Hz) and pressure amplitude (5~15 kPa) was developed, and computational fluid dynamics (CFD) simulations were employed to reveal how pulsating pressure fields influence steam phase change and boundary layer disturbances. A dedicated vacuum pulsation experimental platform was constructed, integrating high-speed micro-imaging and X-ray micro-CT to quantitatively analyze steam penetration depth and 3D distribution under various parameter conditions. Response surface methodology was used to optimize the parameter combinations. The results show that under pulsation conditions, the penetration uniformity index improved by approximately 21%, and the terminal steam saturation reached 0.78±0.05, representing an approximately 50% increase compared to static conditions. At the optimal parameter combination of 1.2 Hz/10 kPa, the unit energy efficiency index (η=5.06 s/J) achieved its highest value, representing an approximate 40% improvement over the baseline, with the corresponding key performance indicator (KPI) reaching 2.37 g/(kW·s), a 58% improvement over the standard. The study confirms that vacuum pulsation parameters can synergistically enhance steam transfer efficiency and energy performance, significantly improving permeation in microscale structures, and providing theoretical guidance and optimization strategies for applications such as microchannel drying, instrument sterilization, and mass transfer in porous media.

Key words: vacuum pulsation, microscale lumen structure, steam penetration efficiency, cycle parameter regulation, CFD simulation

中图分类号:  R197.39

[1] 邹惠芬,王宏伟,刘超翔.带分支结构平板脉动热管的传热性能研究[J].沈阳建筑大学学报(自然科学版),2024,40(6):1054-1059.
[2] 王西龙,罗根松,朱赛赛,等.罗茨真空泵试验方法的研究[J].真空, 2011, 48(2):67-72.
[3] 姚晓霞,林坚,黄丽秀.脉动真空清洗消毒器在腔镜器械清洗中的应用效果[J].中国医疗器械信息,2023,29(1):163-165.
[4] 朱爱群,李云慧子,马秀妮.RCA在脉动真空清洗器清洗管腔类精密器械中的应用研究[J].中国医疗设备,2022,37(3):112-115.
[5] 李伯宁,谷鑫,王衍海,等.影响脉动真空压力蒸汽灭菌器灭菌质量的原因分析及对策[J].中国医学装备,2021,18(6):146-148.
[6] 黄丽平,黄贵玲,郑勤好,等.脉动真空清洗消毒机在管腔器械清洗中的价值探究[J].现代仪器与医疗,2023,29(5):5-9.
[7] 周超,王忠豪,史森中,等.脉动真空灭菌设备校准方法研究[J].中国医学装备,2023,20(4):159-163.
[8] LIU F, SUN Z, BIAN H, et al.Numerical investigation on transport characteristics of hydrogen-air-steam mixture induced by condensation in the single compartment[C]//International Conference on Nuclear Engineering. American Society of Mechanical Engineers, 2022.
[9] 张家安,邓强,马增强,等.基于IMHSA-MSCNN-BiLSTM的风机轴承故障诊断[J].电子测量技术, 2024, 47(7):170-176.
[10] TISCHENDORF C, JANOTTE D, FIORENZANO R, et al.Investigation of energy dissipation in an ejector refrigeration cycle[C]//Proceedings 7th Modelica Conference. 2009.
[11] ALEKSEEV M V, VOZHAKOV I S, SOROKIN A L, et al.Simulation of the outflow of steam from a high-pressure volume into a closed external region[C]//Journal of Physics: Conference Series. IOP Publishing, 2020, 1677(1): 012081.
[12] DINSENMEYER R, FOURMIGUÉ J F, CANEY N, et al.Volume of fluid approach of boiling flows in concentrated solar plants[J]. International Journal of Heat and Fluid Flow, 2017, 65: 177-191.
[13] 周泓,米宏霏,颜美琼.脉动真空清洗消毒器在腔镜器械再处理中的应用[J].护理学杂志,2020,35(14):86-87.
[14] NAFIKOV I, KHUSAINOV R, LUKMANOV R, et al.Justification of parameters of vacuum pumping means with pulsating active flow for cattle farms[J]. Engineering for Rural Development, 2021: 1416-1421.
[15] STOSIAK M, KARPENKO M, SKAČKAUSKAS P, et al. Identification of pressure pulsation spectrum in a hydraulic system with a vibrating proportional valve[J]. Journal of Vibration and Control, 2024, 30(21-22): 4917-4930.
[16] ABDEL-FATTAH Y, SALLAM L, DIEKMANN H.Box-behnken experimental design for optimization of biomass and rthanol yield in saccharomyces cerevisiae[J]. Future Perspectives of Medical, Pharmaceutical and Environmental Biotechnology, 2024, 1(3): 9-14.
[17] YUAN D, ZHOU W, FU T, et al.Experimental and numerical investigation of heat and mass transfer in non-uniform wavy microchannels[J]. International Journal of Thermal Sciences, 2020, 152: 106320.
[18] 李婉清,张广川,曾荟燕,等.基于二项Logistic回归的多种废弃物同载脉动真空灭菌模式研究[J].中国兽医杂志,2023,59(01):64-69.
[19] DU B, ZHANG X.Pulsating vacuum sterilizer[J]. Advanced Materials Research, 2013, 616: 2009-2012.
[20] 吴淑贞,牛畅,冯春月,等.管腔类手术器械采用低温过氧化氢等离子和脉动真空压力蒸汽灭菌的合格率分析[J].黑龙江中医药,2022,51(2):96-98.
[21] 郭诗莹,郑凯龙.低温过氧化氢等离子和脉动真空压力蒸汽灭菌在管腔类手术器械管理中的应用[J].中国医疗器械信息,2024,30(13):164-166.
[22] XU P, ZHU J, XU L, et al.Bionic tree-like microchannel with steady and pulsating flow for thermal management of proton exchange membrane fuel cell[J]. International Journal of Hydrogen Energy, 2024, 93: 328-337.
[23] WANG X, SUN C, JIA S, et al.Flow pattern maps of double emulsions transporting through bifurcation microchannels[J]. Soft Matter, 2024, 20(33): 6544-6557.
[24] 李小金,李正清,韩仙虎,等.基于TRIZ理论的一种提升罗茨真空泵基础压力的设计方法[J].真空, 2024, 61(2):62-67.
No related articles found!
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
[1] 李得天, 成永军, 张虎忠, 孙雯君, 王永军, 孙 健, 李 刚, 裴晓强. 碳纳米管场发射阴极制备及其应用研究[J]. 真空, 2018, 55(5): 1 -9 .
[2] 周彬彬, 张 建, 何剑锋, 董长昆. 基于 CVD 直接生长法的碳纳米管场发射阴极[J]. 真空, 2018, 55(5): 10 -14 .
[3] 柴晓彤, 汪 亮, 王永庆, 刘明昆, 刘星洲, 干蜀毅. 基于 STM32F103 单片机的单泵运行参数数据采集系统[J]. 真空, 2018, 55(5): 15 -18 .
[4] 李民久, 熊 涛, 姜亚南, 贺岩斌, 陈庆川. 基于双管正激式变换器的金属表面去毛刺 20kV 高压脉冲电源[J]. 真空, 2018, 55(5): 19 -24 .
[5] 刘燕文, 孟宪展, 田 宏, 李 芬, 石文奇, 朱 虹, 谷 兵, 王小霞 . 空间行波管极高真空的获得与测量[J]. 真空, 2018, 55(5): 25 -28 .
[6] 徐法俭, 王海雷, 赵彩霞, 黄志婷. 化学气体真空 - 压缩回收系统在环境工程中应用研究[J]. 真空, 2018, 55(5): 29 -33 .
[7] 谢元华, 韩 进, 张志军, 徐成海. 真空输送的现状与发展趋势探讨(五)[J]. 真空, 2018, 55(5): 34 -37 .
[8] 孙立志, 闫荣鑫, 李天野, 贾瑞金, 李 征, 孙立臣, 王 勇, 王 健, 张 强. 放样氙气在大型收集室内分布规律研究[J]. 真空, 2018, 55(5): 38 -41 .
[9] 黄 思 , 王学谦 , 莫宇石 , 张展发 , 应 冰 . 液环压缩机性能相似定律的实验研究[J]. 真空, 2018, 55(5): 42 -45 .
[10] 常振东, 牟仁德, 何利民, 黄光宏, 李建平. EB-PVD 制备热障涂层的反射光谱特性研究[J]. 真空, 2018, 55(5): 46 -50 .