欢迎访问沈阳真空杂志社 Email Alert    RSS服务

真空 ›› 2020, Vol. 57 ›› Issue (3): 37-41.doi: 10.13385/j.cnki.vacuum.2020.03.09

• 测量与控制 • 上一篇    下一篇

内径20mm导向套筒内壁处理(2):空心阴极混合气体放电特性研究*

马玉山1, 常占东1, 刘海波1, 贾华1, 岳玲1, 徐喜龙1, 巩春志2, 田修波2   

  1. 1.吴忠仪表有限责任公司,宁夏 吴忠 751100;
    2.哈尔滨工业大学 先进焊接与连接国家重点实验室,哈尔滨 150001
  • 收稿日期:2019-05-05 发布日期:2020-06-18
  • 通讯作者: 常占东,高级工程师;巩春志,副教授。
  • 作者简介:马玉山(1986-),男,宁夏回族自治区吴忠市人,工学博士,教授级高级工程师。
  • 基金资助:
    国家自然科学基金(No.11875119,No.51811530059);吴忠仪表有限责任公司协同创新项目(WZYB-XTCX-002)

Treatment of Inner Surface of Guide Sleeve with Inner Diameter of20mm: Discharge Characteristics of Mixed Gas Hollow Cathode

MA Yu-shan1, CHANG Zhan-dong1, LIU Hai-bo1, JIA Hua1, YUE Ling1, XU Xi-long1, GONG Chun-zhi2*, Tian Xiubo2   

  1. 1. Wuzhong Instrument Co., Ltd., Wuzhong 751100, China;
    2. State Key Laboratory of Advanced Welding and Joining, Harbin Institute of Technology, Harbin 150001, China
  • Received:2019-05-05 Published:2020-06-18

摘要: 针对高端阀门内径20mm导向套内壁DLC处理,采用高频高压脉冲电源,分别研究了氩气和混合气气氛下脉冲电压、脉宽、频率以及工作气压等参数对管内空心阴极放电伏安特性的影响规律。结果表明:轴向对齐的五个小管内均实现了空心阴极放电,氩气条件下放电电流表现出明显空心阴极放电特征,而混合气条件下电流幅值较为平整。脉冲电压或气压的提高有利于提高放电电流,而脉冲频率的增加会使得峰值电流略有下降,脉宽的增加使得单纯氩气条件下电流峰值逐渐增加,而对于混合其他条件下的峰值电流影响不大,仅使平均电流增加。固定气压10Pa条件下,乙炔流量的变化对放电电流的影响不大,有利于扩大DLC薄膜沉积的工艺窗口范围。以上研究结果为高端阀门小直径导向套等内壁DLC薄膜制备提供工艺基础。

关键词: 阀门, 内壁DLC, 空心阴极, 混合气

Abstract: Aiming at the DLC treatment of inner surface of 20mm guide sleeve of high-end valve, the effects of pulse voltage, pulse width, frequency and working pressure on the volt-ampere characteristics of hollow cathode discharge in tube under argon and mixed atmosphere were studied by using high frequency and high voltage pulse power supply. The results show that the hollow cathode discharge is realized in the five axially aligned tubes. The discharge current under argon condition shows obvious characteristics of hollow cathode discharge, while the current amplitude under mixed gas condition is relatively flat. The increase of pulse voltage or pressure is beneficial to the increase of discharge current, while the increase of pulse frequency decreases the peak current slightly, and the increase of pulse width increases the peak current gradually under the pure argon condition, but has little effect on the peak current under other mixed conditions, only increases the average current. Under fixed pressure of 10 Pa, the change of acetylene flow rate has little effect on discharge current, which is beneficial to enlarge the process window range of DLC film deposition. The above results may provide a technological basis for the preparation of DLC film on inner wall of small diameter guide sleeve of high-end valves.

Key words: valve, inner surface DLC, hollow cathode, mixed gas

中图分类号: 

  • TB71+6
[1] Zheng Z J, Ou G F, Ye H J, et al.Investigation on failure process and structural optimization of a high-pressure letdown valve[J]. Engineering Failure Analysis, August, 2016(66): 223-239.
[2] 李胜亭. 神华煤直接液化项目阀门管道冲蚀磨损及处理措施[J]. 内蒙古石油化工, 2016(7): 36-42.
[3] 偶国富, 饶杰, 章利特, 等. 煤液化高压差调节阀空蚀/冲蚀磨损预测[J]. 摩擦学学报, 2013, 33(2): 155-161.
[4] 张宏, 熊诗波, 梁义维, 等. 液压阀冲蚀磨损特性分析与结构探讨[J]. 煤炭学报, 2008, 33(2): 214-217.
[5] 崔忠圻. 金属学与热处理[M]. 北京: 机械工业出版社, 1999: 315.
[6] 黄可, 马廷灿. 日本NEDO 先进制造研究项目概要[J]. 科学新闻, 2008:12-14.
[7] 高立. 橡树岭的表面改性中心[J]. 国外核新闻, 1993(4):17-18.
[8] Parsi M, Najmi K, Najafifard F, et al.A comprehensive review of solid particle erosion modeling for oil and gas wells and pipelines applications[J]. Journal of Natural Gas Science and Engineering, 2014, 21: 850-873.
[9] 王勇, 张耀锋, 尉伟, 等. 不锈钢管道溅射镀TiN薄膜实验研究[J]. 中国科学技术大学学报. 2007, 37(4-5): 509-513.
[10] 金凡亚, 王珂, 赵嘉学, 等. 内表面等离子体增强化学气相沉积TiN涂层研究[J]. 金属热处理. 2008, 33(8): 93-95.
[11] 石昌仑, 张敏, 林国强. 脉冲偏压对电弧离子镀深管内壁沉积TiN 薄膜的影响[J]. 真空科学与技术学报. 2007, 27(6): 517-521.
[12] 尹利勇, 温小琼, 王德真. 细长金属管内产生的直流辉光等离子体发射光谱诊断[J]. 光谱学与光谱分析, 2008, 28(12): 2745-2748.
[13] Lusk D, Gore M, Boardman W, et al.Thick DLC films deposited by PECVD on the internal surface of cylindrical substrates[J]. Diamond & Related Materials, 2008, 17: 1613-1621.
[14] Wei R .Development of new technologies and practical applications of plasma immersion ion deposition(PIID)[J]. Surface & Coatings Technology, 2010, 204(18):2869-2874.
[15] 吴明忠, 田修波, 李慕勤, 等. 笼网型空心阴极氩气放电特性研究[J]. 真空科学与技术学报, 2015, 35(3): 323-329.
[1] 岳玲, 石月娟, 马玉山, 刘海波, 周永兴, 张明明, 巩春志, 田修波. 内径20mm导向套筒内壁处理(1):空心阴极氩气放电特性研究*[J]. 真空, 2020, 57(2): 53-57.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
[1] 李得天, 成永军, 张虎忠, 孙雯君, 王永军, 孙 健, 李 刚, 裴晓强. 碳纳米管场发射阴极制备及其应用研究[J]. 真空, 2018, 55(5): 1 -9 .
[2] 周彬彬, 张 建, 何剑锋, 董长昆. 基于 CVD 直接生长法的碳纳米管场发射阴极[J]. 真空, 2018, 55(5): 10 -14 .
[3] 李志胜. 空间环境下超大型红外定标用辐射屏蔽门的研制[J]. 真空, 2018, 55(5): 66 -70 .
[4] 郑 列, 李 宏. 200kV/2mA 连续可调直流高压发生器的设计[J]. 真空, 2018, 55(6): 10 -13 .
[5] 柴晓彤, 汪 亮, 王永庆, 刘明昆, 刘星洲, 干蜀毅. 基于 STM32F103 单片机的单泵运行参数数据采集系统[J]. 真空, 2018, 55(5): 15 -18 .
[6] 孙立志, 闫荣鑫, 李天野, 贾瑞金, 李 征, 孙立臣, 王 勇, 王 健, 张 强. 放样氙气在大型收集室内分布规律研究[J]. 真空, 2018, 55(5): 38 -41 .
[7] 黄 思 , 王学谦 , 莫宇石 , 张展发 , 应 冰 . 液环压缩机性能相似定律的实验研究[J]. 真空, 2018, 55(5): 42 -45 .
[8] 纪 明, 孙 亮, 杨敏勃. 一种用于对月球样品自动密封锁紧的设计[J]. 真空, 2018, 55(6): 24 -27 .
[9] 李民久, 熊 涛, 姜亚南, 贺岩斌, 陈庆川. 基于双管正激式变换器的金属表面去毛刺 20kV 高压脉冲电源[J]. 真空, 2018, 55(5): 19 -24 .
[10] 刘燕文, 孟宪展, 田 宏, 李 芬, 石文奇, 朱 虹, 谷 兵, 王小霞 . 空间行波管极高真空的获得与测量[J]. 真空, 2018, 55(5): 25 -28 .