欢迎访问沈阳真空杂志社 Email Alert    RSS服务

真空 ›› 2020, Vol. 57 ›› Issue (2): 53-57.doi: 10.13385/j.cnki.vacuum.2020.02.10

• 测量与控制 • 上一篇    下一篇

内径20mm导向套筒内壁处理(1):空心阴极氩气放电特性研究*

岳玲1, 石月娟1, 马玉山1, 刘海波1, 周永兴1, 张明明1, 巩春志2, 田修波2   

  1. 1.吴忠仪表有限责任公司,宁夏 吴忠,751100;
    2.哈尔滨工业大学 先进焊接与连接国家重点实验室,黑龙江 哈尔滨 150001
  • 收稿日期:2019-05-05 出版日期:2020-03-25 发布日期:2020-04-24
  • 通讯作者: 巩春志,副教授;田修波,教授。
  • 作者简介:岳玲(1976-),女,宁夏回族自治区吴忠市人,工程硕士,工程师。
  • 基金资助:
    *国家自然科学基金(11675047,11875119,51811530059);吴忠仪表有限责任公司协同创新项目(WZYB-XTCX-002)

Treatment of Inner Surface of Guide Sleeve with Inner Diameter of 20mm(1): Characteristics of Argon Hollow Cathode Discharge

YUE Ling1, SHI Yue-juan1, MA Yu-shan1, LIU Hai-bo1, ZHOU Yong-xing1*, ZHANG Ming-ming1, GONG Chun-zhi2*, TIAN Xiu-bo2   

  1. 1.Wuzhong Instrument Co., Ltd., Wuzhong 751100, China;
    2.State Key Laboratory of Advanced Welding and Joining, Harbin Institute of Technology, Harbin 150001, China
  • Received:2019-05-05 Online:2020-03-25 Published:2020-04-24

摘要: 针对高端阀门内径20mm导向套内壁处理,采用高频高压脉冲电源,研究了氩气气氛下工作气压、脉冲电压和频率等参数对导向套空心阴极放电伏安特性的影响,并对工件间距及与阳极距离等放电结构进行了研究。结果表明:管内空心阴极放电需要一个稳定过程,脉冲电流随着时间的增加逐步降低,而后达到稳定放电阶段。提高脉冲电压或工作气压,管内空心阴极脉冲峰值电流增加。脉宽或频率的增加,脉冲峰值电流不变,但平均电流增加,且频率的增加使得激励时间减少。放电结构的分析表明,管间距的减少,放电电流变化不大,而管口与阳极之间距离的减少,使得放电峰值电流略有增加。以上研究结果为高端阀门小直径导向套等内壁薄膜制备提供了有效指导。

关键词: 导向套, 内壁, 空心阴极, 放电特性

Abstract: The influence of working pressure, pulse voltage and frequency on the volt-current characteristics of hollow cathode discharge in argon atmosphere was studied by using high frequency and high voltage pulse power supply for the inner surface treatment of 20mm guide sleeve of high-end valve. Discharge structures such as tube spacing and anode distance were also studied. The results show that the discharge of hollow cathode in tube needs a stable process, and the pulse current decreases gradually with the increase of time, and then reaches a stable discharge stage. The peak current of hollow cathode pulse increases with the increase of pulse voltage or working pressure. With the increase of pulse width or frequency, the peak current of the pulse does not change, but the average current increases, and the excitation time decreases with the increase of frequency. The analysis of discharge structure shows that the peak discharge current increases slightly with the decrease of tube spacing and the decrease of the distance between tube orifice and anode. The above results may provide effective guidance for the preparation of inner wall film such as small diameter guide sleeve of high-end valves.

Key words: guide sleeve, inner surface, hollow cathode, discharge

中图分类号: 

  • TB43
[1] 齐红媛. 水预润湿对液体管道流动阻力特性的影响[J]. 石油化工, (1): 36-41.
[2] 舒利明. 小口径不锈钢管内表面抗黏附机理及其制备技术研究[D]. 大连: 大连理工大学, 2015.
[3] 晁利宁, 余晗, 苑清英, 等. 原油管道清防蜡技术研究进展及应用[J]. 焊管, 2018, 41(12): 60-68.
[4] Pillaca E J D M, Ueda M, Reuther H, et al. Experiments on plasma immersion ion implantation inside conducting tubes embedded in an external magnetic field[J]. Applied Surface Science, 2015, 357: 1438-1443.
[5] Baba K, Hatada R, Flege S, et al.DLC coating of interior surfaces of steel tubes by low energy plasma source ion implantation and deposition[J]. Applied Surface Science, 2014, 310: 262-265.
[6] Ensinger W, Lensch O, Kraus T.Coating the inner walls of metal tubes with carbon films by physical vapor Deposition at low temperature[J]. Surface and Coatings Technology, 2002, 150: 227-231.
[7] Malik S M, Fetheraton R P, Conrad J R.Development of an energetic in assisted mixing and deposition process for TiNx and diamond like carbon films, using a co-axial geometry in plasma source ion implantation[J]. Journal of Vacuum Science and Technology A, 1997, 15: 2875-2878.
[8] 王勇, 张耀锋, 尉伟, 等. 不锈钢管道溅射镀TiN薄膜实验研究[J]. 中国科学技术大学学报, 2007, 37(4-5): 509-513.
[9] 尹利勇, 温小琼, 王德真. 细长金属管内产生的直流辉光等离子体发射光谱诊断[J]. 光谱学与光谱分析. 2008, 28(12): 2745-2748.
[10] 石昌仑, 张敏, 林国强. 脉冲偏压对电弧离子镀深管内壁沉积TiN 薄膜的影响[J]. 真空科学与技术学报, 2007, 27(6): 517-521.
[11] 金凡亚, 王珂, 赵嘉学, 等. 内表面等离子体增强化学气相沉积TiN涂层研究[J]. 金属热处理, 2008, 33(8): 93-95.
[12] Lusk D, Gore M, Boardman W, et al.Thick DLC films deposited by PECVD on the internal surface of cylindrical substrates[J]. Diamond & Related Materials, 2008, 17: 1613-1621.
[13] Wei R.Development of new technologies and practical applications of plasma immersion ion deposition(PIID)[J]. Surface & Coatings Technology, 2010, 204(18): 2869-2874.
[1] 张以忱. 第二十讲 真空离子镀膜[J]. 真空, 0, (): 94-96.
[2] 方波, 张林, 蔡飞, 张世宏. 冷作模具钢等离子渗镀CrVN复合涂层摩擦磨损性能研究*[J]. 真空, 2020, 57(2): 33-39.
[3] 刘灵云, 林松盛, 王迪, 李风, 代明江, 石倩, 韦春贝. CrAlN抗冲蚀涂层制备及性能研究*[J]. 真空, 2020, 57(2): 40-46.
[4] 夏翥杰, 张治国, 王红莉, 苏一凡, 唐鹏, 林松盛, 代明江, 石倩. WO3薄膜制备及其电致变色性能研究*[J]. 真空, 2020, 57(2): 47-52.
[5] 张以忱. 第二十讲 真空离子镀膜[J]. 真空, 2020, 57(2): 94-96.
[6] 陈志涛. 全玻璃真空集热管镀膜设备的发展[J]. 真空, 2020, 57(1): 35-39.
[7] 张以忱. 第二十讲 真空离子镀膜[J]. 真空, 2020, 57(1): 94-96.
[8] 王忠连, 任少鹏, 阴晓俊, 王瑞生, 高鹏, 班超, 胡雯雯. 波长渐变滤光片的设计与测试探讨[J]. 真空, 2020, 57(1): 21-25.
[9] 吴厚朴, 田钦文, 田修波, 巩春志. 新型双极性高功率脉冲磁控溅射电源及放电特性研究*[J]. 真空, 2019, 56(6): 1-6.
[10] 张以忱. 第二十讲 真空离子镀膜[J]. 真空, 2019, 56(6): 85-86.
[11] 李昊, 王东伟, 张川, 刘婵, 黄美东. 电弧离子镀Cr/CrN多层膜的耐腐蚀性研究[J]. 真空, 2019, 56(3): 21-26.
[12] 张以忱. 第二十讲 真空离子镀膜[J]. 真空, 2019, 56(3): 78-80.
[13] 李建, 童洪辉, 但敏, 金凡亚, 王坤, 陈伦江. 场致发射电子源的应用及其研究进展[J]. 真空, 2019, 56(3): 27-31.
[14] 赵陨, 穆佳丽, 李明华, 李文龙, 姚春龙. 基于QFD和DOE的反光镜膜层表面缺陷改进研究[J]. 真空, 2019, 56(3): 32-36.
[15] 李如永, 段苹, 崔敏, 王吉有, 原安娟, 邓金祥. 后退火对射频磁控溅射法制备Mg掺杂Ga2O3薄膜性质的影响[J]. 真空, 2019, 56(3): 37-40.
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
[1] 李得天, 成永军, 张虎忠, 孙雯君, 王永军, 孙 健, 李 刚, 裴晓强. 碳纳米管场发射阴极制备及其应用研究[J]. 真空, 2018, 55(5): 1 -9 .
[2] 周彬彬, 张 建, 何剑锋, 董长昆. 基于 CVD 直接生长法的碳纳米管场发射阴极[J]. 真空, 2018, 55(5): 10 -14 .
[3] 李志胜. 空间环境下超大型红外定标用辐射屏蔽门的研制[J]. 真空, 2018, 55(5): 66 -70 .
[4] 郑 列, 李 宏. 200kV/2mA 连续可调直流高压发生器的设计[J]. 真空, 2018, 55(6): 10 -13 .
[5] 柴晓彤, 汪 亮, 王永庆, 刘明昆, 刘星洲, 干蜀毅. 基于 STM32F103 单片机的单泵运行参数数据采集系统[J]. 真空, 2018, 55(5): 15 -18 .
[6] 孙立志, 闫荣鑫, 李天野, 贾瑞金, 李 征, 孙立臣, 王 勇, 王 健, 张 强. 放样氙气在大型收集室内分布规律研究[J]. 真空, 2018, 55(5): 38 -41 .
[7] 黄 思 , 王学谦 , 莫宇石 , 张展发 , 应 冰 . 液环压缩机性能相似定律的实验研究[J]. 真空, 2018, 55(5): 42 -45 .
[8] 纪 明, 孙 亮, 杨敏勃. 一种用于对月球样品自动密封锁紧的设计[J]. 真空, 2018, 55(6): 24 -27 .
[9] 李民久, 熊 涛, 姜亚南, 贺岩斌, 陈庆川. 基于双管正激式变换器的金属表面去毛刺 20kV 高压脉冲电源[J]. 真空, 2018, 55(5): 19 -24 .
[10] 刘燕文, 孟宪展, 田 宏, 李 芬, 石文奇, 朱 虹, 谷 兵, 王小霞 . 空间行波管极高真空的获得与测量[J]. 真空, 2018, 55(5): 25 -28 .