欢迎访问沈阳真空杂志社 Email Alert    RSS服务

真空 ›› 2018, Vol. 55 ›› Issue (5): 25-28.doi: 10.13385/j.cnki.vacuum.2018.05.05

• • 上一篇    下一篇

空间行波管极高真空的获得与测量

刘燕文 1,孟宪展 2,田 宏 1,李 芬 1,石文奇 1,朱 虹 1,谷 兵 1,王小霞 1   

  1. 1.中国科学院电子学研究所,北京 100190;2.平津战役纪念馆 天津 300131
  • 收稿日期:2018-04-04 出版日期:2018-09-25 发布日期:2018-10-15
  • 作者简介:刘燕文(1964-),男,天津市人,博士,副研究员。

Test of ultra high vacuum in space traveling-wave tube

LIU Yan-wen1, MENG Xian-zhan2, TIAN Hong1, LI Fen1, SHI Wen-qi1, ZHU Hong1, GU Bing1   

  1. 1.The Institute of Electronics, Chinese Academy of Science, Beijing 100080, China; 2.Peking-Tianjin Campaign Memorial Museum, Tianjin 300131, China
  • Received:2018-04-04 Online:2018-09-25 Published:2018-10-15

摘要: 空间行波管广泛应用于雷达、卫星通信等方面,在器件制造过程中,真空是空间行波管工作的 基础条件。利用极高真空排气设备获得了极限真空优于 5×10-9Pa 的空间行波管;采用四级质谱计分析了 空间行波管的排气过程和极限真空状态下的残气质谱,并由此确定了空间行波管经济可行的烘烤排气时 间。利用四极质谱计对空间行波管进行了检漏实验,结果表明四极质谱计具有很高的灵敏度,非常适合极 高真空的检漏。建立了放气量极低的测量空间行波管真空度的测试平台。对空间行波管的老练、高低温实 验、存储等过程的真空度进行了测试。空间行波管在进行老练时,管内真空度下降约一个数量级,经过 140h 老练后,在老练离子泵的抽气作用下,管内真空度上升到 5.0×10-8Pa,这时去掉老练离子泵,其真空 度基本保持不变。最后进行了高低温冲击实验,并在室温下存储 6 个月,真空保持良好。这些结果为分析 空间行波管质量提供了很好的依据。

关键词: 空间行波管, 极高真空, 四极质谱计, 残余气体, 真空测量

Abstract: Spacce traveling-wave tube (STWT) are used in a wide variety of areas, such as radar, space technology and electron accelerators. The vacuum is one of the basic conditions for the work of STWT. We use ultra -high vacuum exhaust station to obtain a microwave device with the ultimate vacuum better than 5 伊 10 -9Pa; The residual gases in a macro-wave device during thermal degassing was in-situ monitored with quadrupole mass spectrometer ( QMS ). The major residual gases, including but not limited to H2O, CO, and H2, was investigated. It is shown that 36 hours was economically for the baking exhaust time. The operating principle and method of vacuum leak detection using QMS are introduced, and the leak detection was conducted for macro-wave device experimentally. Satisfactory results were obtained and showed that QMS has so predominant advantage that no leak detector can get over. A test platform for measuring the vacuum of the microwave device has been established. After the STWT sealing off the exhaust equipment, sophisticated, storage and high and low temperature test process of vacuum was tested. When the STWT is sophisticated, the vacuum in the device is reduced by an order of magnitude. After 140h, the vacuum of the device rises to 5.0 伊 10-8 Pa under the ion pump. At this time, the vacuum remained basically unchanged after removing the ion pump. Finally, high and low temperature impact experiments were performed and stored at room temperature for 6 months, the vacuum of the STWT is kept in good. These results provide a good basis for analyzing the quality of the STWT.

Key words: STWT, ultra high vacuum, quadrupole mass spectrometer, residual gas, vacuum test

中图分类号: 

  • TN107
No related articles found!
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
[1] 李得天, 成永军, 张虎忠, 孙雯君, 王永军, 孙 健, 李 刚, 裴晓强. 碳纳米管场发射阴极制备及其应用研究[J]. 真空, 2018, 55(5): 1 -9 .
[2] 周彬彬, 张 建, 何剑锋, 董长昆. 基于 CVD 直接生长法的碳纳米管场发射阴极[J]. 真空, 2018, 55(5): 10 -14 .
[3] 李志胜. 空间环境下超大型红外定标用辐射屏蔽门的研制[J]. 真空, 2018, 55(5): 66 -70 .
[4] 柴晓彤, 汪 亮, 王永庆, 刘明昆, 刘星洲, 干蜀毅. 基于 STM32F103 单片机的单泵运行参数数据采集系统[J]. 真空, 2018, 55(5): 15 -18 .
[5] 孙立志, 闫荣鑫, 李天野, 贾瑞金, 李 征, 孙立臣, 王 勇, 王 健, 张 强. 放样氙气在大型收集室内分布规律研究[J]. 真空, 2018, 55(5): 38 -41 .
[6] 黄 思 , 王学谦 , 莫宇石 , 张展发 , 应 冰 . 液环压缩机性能相似定律的实验研究[J]. 真空, 2018, 55(5): 42 -45 .
[7] 李民久, 熊 涛, 姜亚南, 贺岩斌, 陈庆川. 基于双管正激式变换器的金属表面去毛刺 20kV 高压脉冲电源[J]. 真空, 2018, 55(5): 19 -24 .
[8] 徐法俭, 王海雷, 赵彩霞, 黄志婷. 化学气体真空 - 压缩回收系统在环境工程中应用研究[J]. 真空, 2018, 55(5): 29 -33 .
[9] 谢元华, 韩 进, 张志军, 徐成海. 真空输送的现状与发展趋势探讨(五)[J]. 真空, 2018, 55(5): 34 -37 .
[10] 常振东, 牟仁德, 何利民, 黄光宏, 李建平. EB-PVD 制备热障涂层的反射光谱特性研究[J]. 真空, 2018, 55(5): 46 -50 .