实验优化设计中频反应溅射Al2O3：Ce薄膜发光性质研究

doi:10.13385/j.cnki.vacuum.2022.01.05

摘要/Abstract

摘要： 为了得到最优发光的薄膜材料成分参数,采用均匀设计和二次通用旋转组合设计相结合的方法建立发光强度与薄膜中氧含量和Ce³⁺离子掺杂浓度的回归方程,并用遗传算法求其取最大值时的解。用中频反应磁控溅射技术制备了相应成分的Al₂O₃：Ce非晶薄膜。在320nm光激发下,获得了较理想的发射光谱,对薄膜发光机理分析表明：薄膜的光致发光来自于Ce³⁺离子的5d¹激发态向基态4f¹的两个劈裂能级的跃迁。发光强度强烈的依赖于薄膜的掺杂浓度和氧元素含量。XPS检测表明,Al₂O₃：Ce薄膜中存在Ce³⁺。Ce³⁺含量和薄膜的化学成分是通过X射线散射能谱（EDS）测量的。薄膜试样的晶体结构应用X射线衍射分析。

关键词: 光致发光, 实验优化, Al₂O₃, 薄膜, 稀土元素

Abstract: The method of optimally designing experiments was introduced to study the properties of Al₂O₃:Ce luminescence thin films.Uniform design and quadratic general rotary unitized design were combined to build the equation between the luminescent intensity and the O^2-/Ce³⁺ doping concentration.Genetic algorithm was introduced into the calculation to obtain the best luminescent intensity.The optimal amorphous Al₂O₃:Ce thin films were deposited by the MF reactive magnetron sputtering technique.Under 320nm ultraviolet excitation,the blue emission spectrum was detected.The luminescence mechanism was studied.The photoluminescence emission from these films was associated with 5d¹ to 4f¹ transitions of Ce³⁺ ions.The intensity of these peaks was strongly dependent on the amount of cerium and oxygen incorporated in the films.There were some Ce³⁺ in the Al₂O₃:Ce thin films by XPS measurement.The presence of cerium as well as the stoichiometry of these films were determined by energy dispersive X-ray spectroscope measurements.The crystalline structure of the sample was analyzed by X-ray diffractometry.

Key words: photoluminescence, experiment optimization, Al₂O₃, thin films, rare earth

中图分类号:

TB43

廖国进, 闫绍峰, 仪登利, 戴晓春. 实验优化设计中频反应溅射Al₂O₃：Ce薄膜发光性质研究[J]. 真空, 2022, 59(1): 24-28.

LIAO Guo-jin, YAN Shao-feng, YI Deng-li, DAI Xiao-chun. The Luminescent Property of Al₂O₃：Ce MFRMS Thin Films Sputtered by Optimal Design of Experiments[J]. VACUUM, 2022, 59(1): 24-28.

参考文献

[1] BUSTA H H.Field emission flat displays vacuum microelectronics[M]. New York: Wiley-Interscience, 2001: 289-295.
[2] OUYANG X, KITAI A H, XIAO T.Electroluminescence of ZnS lumocen devices containing rare-earth and transition-metal fluorides[J]. Journal of Applied Physics, 1996,79: 3229-3231.
[3] REISFELD R, JORGENSEN C K.Optical properties of colorants or luminescent species in sol-gel glasses Structure and Bonding[M]. Berlin: Springer, 1992 : 207-212.
[4] ONO Y A.Encyclopedia of applied physics[M]. Weinheim: VCH, 1993: 295-298.
[5] REISFELD R, JORGENSEN C K.Lasers and excited states of rare earths[M]. Berlin: Springer, 1977: 1-6.
[6] BLASSE G, GRABMAIER B C.Luminescent materials[M]. Berlin: Springer, 1994: 214-218.
[7] GAN F X.Optical and spectroscopic properties of glass[M]. Berlin: Springer, 1992 : 209-212.
[8] 巴德纯, 廖国进, 闻立时, 等. 中频反应磁控溅射制备Al₂O₃:Ce³+薄膜的蓝色发光特性[J]. 真空科学与技术学报, 2006, 26(5):421-424.
[9] 廖国进, 巴德纯, 闻立时, 等.中频反应磁控溅射制备Al₂O₃:Ce薄膜及其光致发光特性[J].稀有金属材料与工程,2008, 37(3): 400-403.
[10] AHMED H A A S, CHAE W S. Interaction mechanism for energy transfer from Ce to Tb ions in silica[J]. Physica B: Condensed Matter, 2016, 480:100-104.
[11] WANG Y F, WANG S.Photoluminescence properties of Ce and Eu co-doped YVO₄ crystals[J]. Journal of Alloys and Compounds, 2013,551: 262-266.
[12] MAJID A, AZMAT M, RANA U A, et al.A computational study of magnetic exchange interactions of 3d and 4f electrons in Ti-Ce co-doped AlN[J]. Materials Chemistry and Physics, 2016, 179: 316-321.
[13] RAKOV N, MACIEL G S.Enhancement of luminescence efficiency of f-f transitions from Tb3+ due to energy transfer from Ce³+ in Al₂O₃ crystalline ceramic powders prepared by low temperature direct combustion synthesis[J]. Chemical Physics Letters, 2004, 400(4-6): 553-557.
[14] ISHIZAKA T, KUROKAWA Y, MAKINO T, et al.Optical properties of rare earth ion(Nd³+, Er³+ and Tb³+)-doped alumina films prepared by the sol-gel method[J].Optical Materials,2001,15:293-296.
[15] MARTINEZ-MARTINEZ R, GARCIA-HIPOLITO M, HUERTA L et al. Studies on blue and red photoluminescence from Al₂O₃ Ce³+ Mn²+ coatings synthesized by spray pyrolysis technique[J]. Thin Solid Films, 2006, 515: 607-610.
[16] ABUD-ARCHILA M, VÁZQUEZ-MANDUJANO D G, RUIZ-CABRERA M A, et al. Optimization of osmotic dehydration of yam bean(Pachyrhizus erosus) using an orthogonal experimental design[J]. Journal of Food Engineering, 2008, 84(3): 413-419.
[17] 任露泉. 试验设计及其优化[M]. 北京: 科学出版社, 2009: 174-180.
[18] 何为,薛卫东,唐斌.优化试验设计方法及数据分析[M]. 北京: 化学工业出版社, 2012: 191-194.
[19] 程仕平,徐慧,王德志,等. 基于二次通用旋转组合设计的MoO₂氢还原工艺优化研究[J].稀有金属材料与工程, 2007,36: 1933-1938.
[20] XIONG W W, YIN C L, ZHANG Y, et al.Series-parallel hybrid vehicle control strategy design and optimization using real-valued genetic algorithm[J]. Chinese Journal of Mechanical Engineering, 2009,22(6):862-868.
[21] TAN G Z, ZHOU D M, JIANG B J.Elitism-based immune genetic algorithm and its application to optimization of complex multi-modal functions[J]. Journal of Central South University of Techonlogy, 2008, 15:845-852.
[22] TAYA B K, ZHAOA Z W, CHUA D H C. Review of metal oxide films deposited by filtered cathodic vacuum arc technique[J]. Materials Science and Engineering R,2006, 52(1-3): 1-48.
[23] 任露泉. 回归设计及其优化 [M]. 北京: 科学出版社, 2009: 54-69
[24] SCHNEIDER W D, LAUBSCHAT C, NOWIK I, et al.Shake-up excitations and core-hole screening in Eu systems[J]. Physical Review B, 1981, 24(9): 5422-5425.
[25] SIGNORELLI A J, HAYES R G.X-ray photoelectron spectroscopy of various core levels of lanthanide ions: The roles of monopole excitation and electrostatic coupling[J]. Physical review B, 1973, 8(1): 81-87.
[26] WERTHEIM M, CAMPAGNA G K.Screening of 3d holes in the rare earths[J]. Solid State Communications, 1978, 26(8): 553-556
[27] 孙家跃, 杜海燕, 胡文祥. 固体发光材料 [M]. 北京: 化学工业出版社, 2003: 97-112.
[28] KEIKO A, HIROSHI T, KEIICHI T, et al. Annealing effects on luminescence from Ce-implanted α-Al₂O₃[J]. Nuclear Instruments and Methods in Physics Reseach B, 2001, 175-177: 580-584.
[29] NEHRU L C, MARIMUTHU K, JAYACHANDRAN M et al. Ce³+-doped stillwellites: A new luminescent system with strong ion lattice coupling[J]. J. Phys. D: Appl. Phys.2001, 34(17): 2599-2605.
[30] FALCONY C, GARCYA M, ORTIZ A, et al.Blue photoluminescence from CeCl₃ doped Al₂O₃ films[J]. Journal of the Electrochemical Society, 1994, 141:2860-2870.
[31] POORT S H M, BLASSE G. The influence of the host lattice on the luminescence of divalent europium[J]. Journal of Luminescence, 1997, 72-74:247-249.

Metrics

Viewed

Full text

Abstract

Cited

Shared

Discussed

实验优化设计中频反应溅射Al₂O₃：Ce薄膜发光性质研究

The Luminescent Property of Al₂O₃：Ce MFRMS Thin Films Sputtered by Optimal Design of Experiments

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

Metrics

本文评价

推荐阅读 10

[1]	刘沅东. 磁控溅射制备大面积ZnO薄膜性能的研究[J]. 真空, 2022, 59(1): 29-32.
[2]	段珊珊, 施昌勇, 杨丽珍, 刘忠伟, 张海宝, 陈强. 原子层沉积法制备Al₂O₃薄膜研究近况和发展趋势[J]. 真空, 2021, 58(6): 13-20.
[3]	朱蓓蓓, 倪昌, 秦琳, 楚建宁, 陈肖, 许剑锋. 基于磁控溅射的纳米金属薄膜沉积工艺研究^*[J]. 真空, 2021, 58(6): 21-26.
[4]	杨曌, 罗俊尧, 李保昌, 李淑华, 沓世我, 付振晓, 宁洪龙. 复合金属薄膜层对金丝键合性能的影响[J]. 真空, 2021, 58(6): 43-47.
[5]	陈谦, 杨丽珍, 刘忠伟, 张海宝, 陈强. 分子层沉积纳米薄膜的现状和发展[J]. 真空, 2021, 58(5): 26-31.
[6]	魏梦瑶, 王辉, 韩文芳, 王红莉, 苏一凡, 唐春梅, 代明江, 石倩. 中频磁控溅射制备氧化钨薄膜及电致变色性能研究^*[J]. 真空, 2021, 58(5): 50-56.
[7]	张晓霞, 邓金祥, 孔乐, 李瑞东, 杨子淑, 张杰. 不同浓度的Si掺杂β-Ga₂O₃薄膜的制备及研究^*[J]. 真空, 2021, 58(5): 57-61.
[8]	张健, 牛夏斌, 李建浩, 齐振华. 射频磁控溅射对PET基材制备铝薄膜的性能影响[J]. 真空, 2021, 58(4): 21-24.
[9]	任少鹏, 高鹏, 王瑞生, 金秀, 王忠连, 张轶. 《荧光检测分析用干涉滤光片》标准解析[J]. 真空, 2021, 58(4): 25-29.
[10]	纪建超, 颜悦, 哈恩华. 溶胶-凝胶法制备AZO薄膜的研究进展^*[J]. 真空, 2021, 58(4): 30-35.
[11]	谭彪, 黄涛, 王鹏程, 刘佳明, 关玉慧, 刘顺明, 孙晓阳, 董海义. 中国散裂中子源RCS真空系统^*[J]. 真空, 2021, 58(3): 1-6.
[12]	杨子淑, 段苹, 邓金祥, 张晓霞, 张杰, 杨倩倩. 不同浓度的Mg掺杂β-Ga₂O₃薄膜的制备与研究^*[J]. 真空, 2021, 58(3): 30-34.
[13]	周美丽, 施昌勇, 陈强. 微波表面波对管内壁沉积DLC薄膜的均匀性的研究[J]. 真空, 2021, 58(3): 39-44.
[14]	张心会, 李青霄. 真空热处理对AZO膜结构及光电性能的影响^*[J]. 真空, 2021, 58(3): 45-50.
[15]	高鹏, 班超, 任少鹏, 金秀, 王忠连, 杨文华. 一种基于遗传算法的光学薄膜优化设计方法^*[J]. 真空, 2021, 58(2): 27-30.